Volvo S60 Water Pump Replacement at your home or office.

Our mobile mechanics offer services 7 days a week. Upfront and transparent pricing.

Estimate price near me

Service Location

Customer Ratings

(3)

Included for free with this service

Online Booking

Mechanic comes to you

12-month / 12k-mile warranty

Free 50 point safety inspection

Our certified mobile mechanics can come to your home or office 7 days a week between 7 AM and 9 PM.

Customer Ratings

(3)

Water Pump Replacement Service

How much does a Water Pump Replacement cost?

On average, the cost for a Volvo S60 Water Pump Replacement is $466 with $116 for parts and $350 for labor. Prices may vary depending on your location.

CarServiceEstimateShop/Dealer Price
2009 Volvo S60L5-2.5L TurboService typeWater Pump ReplacementEstimate$1064.08Shop/Dealer Price$1224.65 - $1682.06
2002 Volvo S60L5-2.4LService typeWater Pump ReplacementEstimate$1037.05Shop/Dealer Price$1192.32 - $1645.76
2005 Volvo S60L5-2.4L TurboService typeWater Pump ReplacementEstimate$1037.05Shop/Dealer Price$1192.40 - $1645.89
2002 Volvo S60L5-2.3L TurboService typeWater Pump ReplacementEstimate$1037.05Shop/Dealer Price$1192.39 - $1645.88
2014 Volvo S60L5-2.5L TurboService typeWater Pump ReplacementEstimate$1110.05Shop/Dealer Price$1271.47 - $1729.53
2006 Volvo S60L5-2.5L TurboService typeWater Pump ReplacementEstimate$1037.05Shop/Dealer Price$1192.82 - $1646.62
2007 Volvo S60L5-2.4L TurboService typeWater Pump ReplacementEstimate$1037.05Shop/Dealer Price$1192.44 - $1645.97
2005 Volvo S60L5-2.5L TurboService typeWater Pump ReplacementEstimate$1037.05Shop/Dealer Price$1192.39 - $1645.88
Show example Volvo S60 Water Pump Replacement prices

What is a water pump and how does it work?

The water pump is a belt or chain-driven engine accessory bolted to the engine above the crankshaft pulley. The pump housing has an impeller that circulates engine coolant through the cooling system passageways in the engine block and cylinder head, on to the radiator, where the coolant temperature is reduced. . The lower temperature coolant then flows back to the water inlet on the engine and the water pump continues the cycle.

When to consider replacing the water pump:

  • Coolant leaks or overheating. The water pump impeller shaft is supported by a bearing. Eventually, the bearing or seal can wear and leak or damage the impeller. Many water pumps have weep holes near the pump bearing. If you see significant leakage from that weep hole, it is time to replace the pump.
  • Bearing roughness or noise. If the water pump shaft does not turn smoothly or the pump is noisy, the bearing is excessively worn. Pump replacement will be necessary.
  • Timing belt replacement. In engines where the water pump is driven by the timing belt, it is a good idea to replace the water pump at the same time the timing belt is replaced. The extensive work explains why it is always recommended to replace the water pump whenever the mechanic already has these components removed for regularly scheduled timing belt replacement.

How do mechanics replace the water pump?

  • The water pump is usually bolted to the front of the engine. The replacement procedure will vary depending on whether the pump is driven by the timing belt, the serpentine belt, or chain.
  • On a cold engine, the engine coolant is drained to a level below the water pump.
  • Components that require removing to access the water pump are removed, including the belt or chain that directly drive the pump.
  • The bolts holding the pump to the engine are removed and the pump is pulled out.
  • The gasket surface must be cleaned and the pump mounting surface inspected. A new gasket, rubber seal, or RTV sealant, as required, is installed and then the new pump. The bolts are torqued in sequence using a calibrated inch pound torque wrench.
  • For applications where the water pump is driven by the timing belt, the timing belt must be removed. Typically, this requires removal of the crankshaft pulley, timing belt covers, and timing belt tensioner. Once the new pump is installed, new coolant is added back while bleeding the cooling system of any air. The engine is then run and brought to normal operating temperature to check for leaks and ensure normal operating temperature.

Is it safe to drive with a water pump problem?

No. Should the water pump only leak a little bit, you can drive the car. However, a small leak could suddenly enlarge or the pump bearing might unexpectedly seize. Either circumstance would likely cause engine overheating. If a defective water pump causes the overheating, it is not safe to drive because of the damage to the engine.

When replacing the water pump keep in mind:

  • It is best to install a new cooling system thermostat when you install a new water pump, especially if the thermostat is old or original.
  • Completely flushing the cooling system is a good idea when you replace the water pump. Flushing can be done before or after pump replacement.
  • The rest of the cooling system should be inspected too — particularly rubber hoses, which have a limited lifetime.

Fast and easy service at your home or office

Backed by 12-month, 12.000-mile guarantee


Meet some of our expert Volvo mechanics

Real customer reviews from Volvo owners like you.

Excellent Rating

(3)

Rating Summary
2
0
0
0
1
2
0
0
0
1

Excellent Rating

(3)

Rating Summary
2
0
0
0
1
2
0
0
0
1
Number of Volvo S60 Water Pump Replacement services completed
33+
services done by our mechanics
TOTAL NUMBER OF EXPERT Volvo MECHANICS
600+
experts on our platform

Recent articles & questions

P2049 OBD-II Trouble Code: Reductant Injector Circuit High Voltage Bank 1 Unit 1
P2049 P2049 code definition Reductant Injector Circuit High Voltage Bank 1 Unit 1 What the P2049 code means This code indicates there is a problem with the electrical circuit that controls the reductant injector. What causes the P2049 code? The...
A Buyer’s Guide to the 2012 Lexus GX 460
It It may be hard to believe, but luxury and adventure can go hand in hand – especially with the 2012 Lexus GX 460. From its luxurious interior with a variety of features to its high-quality build, off-road prowess and...
How to Buy a Personalized License Plate in South Carolina
Personalized Personalized license plates are a great way to add a little flair and unique feel to your vehicle. A personalized plate allows you to choose the numbers and digits on your license plate, so that you can have your...

How do you program a new personal entry code into the keyless entry system?

If your car is equipped with the keyless entry keypad, it came with a default access code. This five-digit code lets you work the locks from the keypad. However, you can also change it to something else if you prefer....

How do I reset the sunroof?

If your battery has been disconnected or replaced, then the sunroof will need to be reset before it will start working properly. To reset the sunroof, follow these steps: 1. Turn the ignition to the ON position. 2. Push the...

on/off humming buzzing noise on highway

Hey there, it looks like there was a problem with the link you added. However, from what you described, it sounds like the noise may be the cooling fan coming on and off as you are driving. Check the cooling...

How can we help?

Our service team is available 7 days a week, Monday - Friday from 6 AM to 5 PM PST, Saturday - Sunday 7 AM - 4 PM PST.

1 (855) 347-2779 · hi@yourmechanic.com