Skip the auto shop - Our mechanics make house calls

Q: Green AC oil coming out Condesation line after Recharge?

asked by on

AC was blowing warm, hooked up a can of refrigerant, psi read 15psi, charged with compressor engaged to around 40psi. Air then was cold. came out 15 min later green slime all down frame and on ground. No visible leak at fire wall , no visible leaks anywhere else but out of drip tube. Recharged a day later after 10 min drip becomes green and psi slowly drops. Evaporator? ORINGS? any help is greatly appreciated.

My car has 70000 miles.
My car has an automatic transmission.

A: If you are seeing the green oil dye coming ...

If you are seeing the green oil dye coming out of the A/C evaporator drain tube then you most likely have a leaking evaporator or expansion valve on the evaporator. The green dye can be seen using yellow glasses and a black light.

You can have the Freon reclaimed and remove evaporator. Use a black light and yellow lens glasses to find the leak on evaporator. Before you do this, I'd also suggest using the light and glasses to look over the entire system to see if there are any other leaks present. Make sure to check compressor and condenser good.

If you need some help with these checks consider enlisting a certified mechanic, such as one from YourMechanic. They will be able to help you diagnose the source of the leak and make the necessary repairs.

Was this answer helpful?

Need advice from certified mechanic? Get help now!

Over 1000 mechanics are ready to answer your question.
The statements expressed above are only for informational purposes and should be independently verified. Please see our terms of service for more details

Ask a Mechanic
(100% Free)

Have a car question? Get free advice from our top-rated mechanics.

Ask A Mechanic
Over 10,000 questions answered!

Get an instant quote for your car

Our certified mechanics come to you ・Backed by 12-month, 12,000-mile guarantee・Save up to 30%

Get a quote

What others are asking

Q: Power steering leaking fluid

The first step is to identify the leaks. Most of the time it's a faulty line, other times it's the pump that is leaking, and if the pump has been run low on fluid, the pump may need replacing if...

Q: Leaking brake fluid

Depending on where the line is leaking, the brake system should be checked throughly for rusted out brake lines to find out if more than one problem exists. The system should be checked by a certified mechanic to check your...

Q: Truck overheated and engine shut off. Should I have the motor rebuilt?

If the engine was checked by the repair shop and it's running fine, then leave it alone. You may or may not ever have any issues related to the overheat. There is really no way to predict. You can maybe...

Related articles

How Long Does a Distributor O Ring Last?
The distributor is part of the ignition system in your vehicle and its purpose is to route high voltage from the ignition coil to the spark plug. The spark plug then...
How to Renew Your Car Registration in Oklahoma(DELETED)
Having your car registered with the Oklahoma Tax Commission is an important part of driving legally in this state. You will need to do this within 30 days of moving to Oklahoma...
P2103 OBD-II Trouble Code: Throttle Actuator Control Motor Circuit High
P2103 means there is a fault with the throttle actuator control motor circuit, likely due to a defective electrical component or part.