Q: Car dies when I fill tank up to full every time

asked by on

Everytime I fill my gas to full it'll die about 5 or 6 times after that it'll run fine all the way to empty...no check engine light ..local shop said everything was fine but problem still occurs

My car has 63000 miles.
My car has an automatic transmission.

Hello, Your car has a small purge valve called a purge solenoid that controls the venting of fumes from the fuel tank as these fumes build up inside, particularly when you are refueling the car with gas. The EVAP system prevents fuel vapors from the fuel tank from escaping into the atmosphere. The EVAP system collects and temporarily stores the fuel vapors in the charcoal canister. The charcoal canister is filled with activated carbon pellets that can absorb the fuel vapors. When the engine is running, the fuel vapors are purged from the canister and burned in the engine. The vent control valve (solenoid) controls the flow of outside air in and out of the charcoal canister. The vent valve is controlled by the engine computer (PCM). Normally the vent valve is open. It closes when the engine computer tests the EVAP system for leaks. If a leak in the EVAP system is detected, the Check Engine light will illuminate on the dash and the trouble code related to the problem will be stored in the engine computer. When an air leak is present in the EVAP system, the MAP sensor will not be able to determine the air density, and the MAF sensor will not be able to determine the volume of air, entering the engine correctly. This will lead to an over fueling situation or an under fueling situation depending on the size of the air leak and engine operating speeds and load. This may eventually lead to catalytic converter problems as well as misfiring problems. I would recommend having an expert from Your Mechanic come to your location to diagnose and inspect your vehicle.

Was this answer helpful?
The statements expressed above are only for informational purposes and should be independently verified. Please see our terms of service for more details
  1. Home
  2. Questions
  3. Car dies when I fill tank up to full every time

Get an instant quote for your car

Our certified mechanics come to you ・Backed by 12-month, 12,000-mile guarantee・Fair and transparent pricing

Get a quote

What others are asking

Q: I have a 2003 Durango, I rebuild the whole engine and cooling system but still overheats when Im in a stop or in slow traffic

Hi there. Typically an overheating problem is caused by either a restriction of coolant flowing through the cooling system or the radiator fan not cooling the radiator. In most cases, when people completely rebuild an engine, they will replace the...

Q: I have a 2006 Mitsubishi Galant SE I've had tire rods done I've had the front brakes done front rotors done but now I smell a burn

Whenever a tie rod is removed from a vehicle, upon re-installation (of a new or used tie rod), the toe-in (a key front end alignment specification) must be carefully adjusted. Based on factory specifications, the preferred toe-in setting for your...

Q: Q: Misfire on cylinder 8

It could be the spark plug, ignition coil, or coil boot causing the misfire. You may also have dirty fuel injectors that need to be cleaned. Have the ECM scanned to see if the misfire code is P0308. This code...

Related articles

How Do Power Car Windows Increase Passenger Safety?
Power windows are responsible for approximately 2,000 emergency room visits every year. When a power window closes, it exerts enough force to bruise or break bones, crush fingers, or restrict an airway. Though...
How Much Does a Mechanic Make in Vermont?
Automotive technician jobs in Vermont have an average mechanic salary of $37k, with some mechanics earning a salary of $53k.
P2103 OBD-II Trouble Code: Throttle Actuator Control Motor Circuit High
P2103 means there is a fault with the throttle actuator control motor circuit, likely due to a defective electrical component or part.